引用本文:
【打印本页】   【HTML】   【下载PDF全文】   【EndNote】   【RefMan】   【BibTex】
←前一篇|后一篇→ 过刊浏览    高级检索
本文已被:浏览 1237次   下载 368  
分享到: 微信 更多
应变对PH13-8Mo 钢在1 050 ~1 150时变形组织的影响
舒小勇 鲁世强 郑海忠 刘大博 金建军
南昌航空大学材料科学与工程学院
摘要:
采用Gleeble 热模拟试验机,对PH13-8Mo 钢进行热变形模拟实验,研究了应变对PH13-8Mo 钢在
应变速率为10/ s,变形温度为1 050 ~1 150益时变形组织的影响。结果表明,PH13-8Mo 钢在1 050益、应变达到
0.69 时仍未发生完全再结晶,但在1 100 和1 150益、应变分别达到0. 29 和0. 24 后,发生了明显的完全再结晶。
再结晶体积分数随应变增加和变形温度升高而逐渐增大,直至发生完全再结晶。当应变<0. 29 时,再结晶晶粒尺
寸和试样的平均晶粒尺寸随应变增加较快地减小;当应变>0.29 后,再结晶晶粒尺寸和试样的平均晶粒尺寸随应
变增加缓慢地减小。再结晶晶粒尺寸和试样的平均晶粒尺寸均随变形温度的升高而增大。
关键词:  PH13-8Mo 钢,应变,变形组织,再结晶
DOI:
分类号:
基金项目:
Effect of Strain on Microstructure Evolution of PH13-8MoSteel Deformed at 1 050 to 1 150
Abstract:
The influence of strain on deformation microstructure evolution of PH13-8Mo steel was investigated
through isothermal compression tests using Gleeble thermal mechanical simulator within the temperature range of 1 050 to 1 150 and with the strain rate of 10/ s. The results show that dynamic recrystallization occurs partially when the strain reaches maximum 0. 69 at 1 050. However, at 1 100 and 1 150, full dynamic recrystallization has occurred when the strain reaches 0. 29 and 0. 24, respectively. The fraction of recrystallization increases with increasing strain and deformation temperature. The recrystallized grain size and average grain size of the impacted steel markedly reduce with the strain before the strain reaches 0. 29, then slowly reduce. However, the recrystallized grain size and average grain size of the impacted steel both increase with increasing deformation temperature.
Key words:  PH13-8Mo steel, Strain, Deformation microstructure, Recrystallization